My State:
Free Special Reports
Get Your FREE Special Report. Download Any One Of These FREE Special Reports, Instantly!
Featured Special Report
Claim Your Free Copy of 2018 EHS Salary Guide

This report will help you evaluate if you are being paid a fair amount for the responsibilities you are shouldering.

In addition, EHS managers can find the information to keep their departments competitive and efficient—an easy way to guarantee you are paying the right amount to retain hard-to-fill positions but not overpaying on others.

Download Now!
Bookmark and Share
July 17, 2018
Defective forklifts cause CO poisoning

Carbon monoxide (CO) in quantities that exceed OSHA’s permissible exposure limit (PEL) of 50 parts per million (ppm) as an 8-hour time-weighted average (29 CFR 1910.1000 Table Z-1) can occur in indoor work areas where fuel with a carbon content (e.g., natural gas, gasoline, kerosene, oil, propane, coal, wood, or plastic) is incompletely combusted. One of the most common indoor sources of CO are forklifts that have not been properly maintained or for which a dilution flow of air has not been established.

For a Limited Time receive a FREE Safety Special Report on the "50 Tips For More-Effective Safety Training."  Receive 75 pages of useful safety information broken down into three training sections. Download Now

This hazard was recently reported by OSHA in conjunction with an investigation into an Illinois-based pallet manufacturer. According to the agency’s citation, the company allowed its workers to operate defective forklifts that were generating nearly 10 times the PEL. Despite alarms from CO detectors, OSHA states that the employer continued to allow the employees to work in the hazardous area. Ten employees required emergency medical treatment for CO exposure. The company is facing penalties totaling $216,253.

Silent killer

Once inhaled, CO displaces oxygen in the blood and deprives the heart, brain, and other vital organs of oxygen. CO has long been known as a “silent killer” for two reasons. First, the gas is colorless, odorless, and tasteless and, alone, cannot be detected by workers; CO may combine with other gases that do carry an odor. Second, exposure to unsafe levels of CO can produce symptoms that may not be associated with CO poisoning. For example, exposure to 200 ppm (0.02 percent CO in the air) can cause headaches, fatigue, nausea, and dizziness, symptoms more commonly brought on by the flu. While short-term CO exposure at 200 ppm will not typically produce serious illness, continued exposure at that level can result in a dangerous accumulation of CO in the blood.

Once exposure reaches 800 ppm, the risk of death enters the picture if exposure is prolonged. Very high exposure levels (e.g., 12,000 ppm) will result in almost instant death. According to a fact sheet published by the Communication Workers of America ((CWA), CO causes more deaths than any other toxic agent except alcohol.

“At least another 10,000 workers suffer from the debilitating effects of high-level exposure,” says the CWA. “Millions more are subject to low-level, long-term CO exposure, the effects of which are not well defined.”

Mitigating the hazard

In a fact sheet, OSHA says employers can implement the following measures to reduce the chances of CO poisoning in employees:

  • Install an effective ventilation system that will remove CO from work areas.
  • Maintain equipment that can produce CO in good working order to promote its safe operation and reduce CO formation.
  • Consider switching from gasoline-powered equipment to equipment powered by electricity, batteries, or compressed air.
  • Prohibit the use of gasoline-powered engines or tools in poorly ventilated areas.
  • Provide personal CO monitors with audible alarms if potential exposure to CO exists.
  • Test air regularly in areas where CO may be present, including confined spaces (see 29 CFR Part 1910.146—Confined Spaces).
  • Install CO monitors with audible alarms.
  • Use a full-face piece pressure-demand self-contained breathing apparatus (SCBA) certified by the National Institute for Occupational Safety and Health (NIOSH) or a combination full-face piece pressure demand supplied-air respirator with auxiliary self-contained air supply in areas with CO concentrations immediately dangerous to life and health atmospheres (see 29 CFR 1910.134—Respirators).
  • Use respirators with appropriate canisters for short periods under certain circumstances where CO levels are not exceedingly high.
  • Educate workers about the sources and conditions that may result in CO poisoning as well as the symptoms and control of CO exposure.

In addition, OSHA’s confined space standard requires that employers ensure that workers test for oxygen sufficiency before permitting employees to enter a confined space where the presence of CO is suspected.

OSHA’s fact sheet is available here.

Featured Special Report:
2018 EHS Salary Guide
   
   
 
 
Twitter  Facebook  Linked In
Follow Us
Copyright © 2019 Business & Legal Resources. All rights reserved. 800-727-5257
This document was published on https://Safety.BLR.com
Document URL: https://safety.blr.com/workplace-safety-news/equipment-and-process-safety/forklift-safety/Defective-forklifts-cause-CO-poisoning/